What HP Tune to run?

[08FX4RBP]

What HP tune would be safe to run on the streets for a daily driven vehicle?:shrug:

[soutthpaw]

Not sure what options Bill has for the 6.4 but the 7.3 really does well on the 80 and 100HP tunes around town. I use the 100 quite a bit because it has great throttle response of the line and at light throttle. Crusing, I run the Fuel Sipper which is similar to the 80HP tune with some fuel and shift point mods... Plus my own mods I made to that tune. The 80 and 100HP are very similar if you are not laying into the throttle all the time.. There are several comment on the forum from folks who really like the 80HP for a daily driver

[08FX4RBP]

Currently im running the 100 hp/180 tq tune around town and seems to be running good. How often do these truck usually go into regen??

[jasfaa]

I run mine on the highest factory tune. Can't remember what that HP is anymore but it gives me the best performance as well as fuel mileage. (17 to 18 mpg on highway). My only issue has been tranny ones at this level. The electronics in the tranny seem to have an issue with this power level and make it shift funny even after the latest updates from Ford. not sure what to do about it but right now I am too busy to look into it further.

[88Racing]

From what this gasser understands is the 80 or 100 tunes are probably the best choice for DD out there.

Lars

[jasfaa]

The lower tunes do not improve fuel mileage from what I understand and personal experience. This has been true on all of the chips out there.

[88Racing]

The lower tunes do not improve fuel mileage from what I understand and personal experience. This has been true on all of the chips out there.
Agreed, but what the common every day person would like to run is not the max hp program available. The 80+100 tunes have better throttle response than stock. Agreed also that the max hp program is going to be even be bettr than this.
Problems with your tranny? Have you put it back to stock to see if it does it there too? Or like you said ford's "updates"?

Lars

[jasfaa]

the issue is at all levels but most noticeable at the highest tune. What I do is disconnect both battery cables and then the "intelligent" POS resets and all is good for a while. I think the way to go on this thing is an engine and tranny tune. The learning capability of these things seems to be an issue. This is my first auto in a diesel and I am not impressed. I do drive in flat and then mountainous terrain though so it is probably partially my driving habits too. With my 6 speed manual this was never an issue. :cheesy smile:

As for the tunes, I found the highest was better than the stock, economy, towing and the first power setting. I tried all of them on a 10 hour round trip drive I was doing over and over and I would switch each time I went. for me it is either stock or the top tune it came with. The others just did not seem to do much on mileage which is why I bought it to begin with.

[Power Hungry]

Regen frequency depends on which calibration series you are running. Older cals seemed to regen less frequently, but for longer periods of time. The new ones regen more often but for shorter periods.

[Power Hungry]

Jason,

What is the current calibration version you're running? We have an update coming out in a couple days that helps address some of those shifting issues and seems to be a bit better on economy as well.

[jasfaa]

Bill,

Once again I am on the road and will have to look when I get home.

I hope you are feeling better.

Jason.

[08FX4RBP]

Will you let us know when the update is available?

[Power Hungry]

Will do. :)

[08FX4RBP]

I have been running on level 3, bumped it up to level 4...saw a mileage improvement over the level 3 and also a power increase. Is it safe to run it all the time on 4 or just keep with the 3?:shrug:

[Power Hungry]

Keeping foot out of it, Level 4 works fine. I have a number of customers who run nothing except Level 4.

We had to go back in and make a few more changes to the calibrations this week to address a couple small issues. If all is good through Friday, we'll release this weekend. :)

Take care.

[jasfaa]

Jason,

What is the current calibration version you're running? We have an update coming out in a couple days that helps address some of those shifting issues and seems to be a bit better on economy as well.

Bill,

I am on calibration 1.2.681. The tranny shift issue is not as bad as it was since it only happened once since the latest updates and it was not as bad as we have discussed in the past. Not even close but still there a little bit. Let me know when the update is available and I will try it out.

[jasfaa]

I run mine on level 4 all of the time. Even when I have a load. Just have to watch your EGT's going up hill. Still would like to see if removing the DPF would help with lowering the EGT's or allow for a higher tune because of the lower temps like others have discussed in other forums.

Yes, I know it is not "legal" but damn I miss the smell of exhaust.