|
|
|||||||
| 1999 to 2003 7.3L Power Stroke Diesel 7.3L Power Stroke Diesel equipped Super Duty and Excursion |
 |
|
|
Thread Tools | Display Modes |
|
#11
Thu, October 6th, 2011, 02:55 PM
|
|||
|
|||
Which is harder to work on?
__________________
01 F350 7.3 4x4 CC SRW/3.73/315-75-16/Aeroforce Interceptor/BD Thruster II/ Bellowed Up-Pipes/4" turbo back exhaust/CCV Mod/DIY 6637/FPR Shimmed to 65 PSI/TS chip reburned with PHP tunes (Stock, 40T WITH Whsiper tune, 80DD, 100R, 140Ex, 140SS)/Replaced and Cleaned EBPS & Tube 4-6-12/Zoodad mod/Recon smoked cab lights/MM Hubs/Cowl Hood/HPx 
|
|
#12
Wed, October 12th, 2011, 09:16 AM
|
||||
|
||||
|
Quote:
 Oh wait....sometimes they don't. My ZF6 tossed out the springs in the clutch, then the slave cyl failed, and then the clutch fork bent and failed..... and then and finally then the whole trans failed at ~70k. It lost the pocket bearing. I just exchanged it with the HO version thats in the 02-03's($1900). So far so good. I still perfer it for towing vs, 4R100's or the 5R110's. With the US gear OD behind it, it make for a awesome towing machine, Always in the right gear...If it had a high HP truck with injectors, big oil and turbos, I'd run a 4R100 too, just for the fun factor. 
__________________
19 F-350 6.7 Auto 16 F-350 6.7 Auto 05 Excursion 6.0, Auto, PHP Atlas 40 FICM, ARP Studs VXBC6(truck PCM) 00 F-350 7.3, 12 Speed, PHP Gryphon, PHP hydra, DAC3 95 F-Superduty 7.3 DI, Auto, Mechanics Truck 94 F-Superduty 7.3 DI, 5 speed, Flatbed
|
|
#13
Wed, October 12th, 2011, 09:30 AM
|
||||
|
||||
|
What is the US gear with OD? and would I want one?
|
|
#14
Wed, October 12th, 2011, 12:05 PM
|
|||
|
|||
|
Its a gear splitter, gives you like an in-between gear (1st, 1st-over, 2nd, 2nd-over...) Mounts between the transmission and differential. It helps the rpms from falling so much when pulling. I'm not sure if US Gear makes them anymore....I know Gear Vendor does...you can pick one up for $3k IIRC. If you do a lot of heavy towing it would be handy to have. I don't know what kind of power output they are rated too though. I think I've seen some 500hp trucks with Gear Vendors unit in Diesel Power.
My rebuild with some upgrades was $2100.
__________________
01 F350 7.3 4x4 CC SRW/3.73/315-75-16/Aeroforce Interceptor/BD Thruster II/ Bellowed Up-Pipes/4" turbo back exhaust/CCV Mod/DIY 6637/FPR Shimmed to 65 PSI/TS chip reburned with PHP tunes (Stock, 40T WITH Whsiper tune, 80DD, 100R, 140Ex, 140SS)/Replaced and Cleaned EBPS & Tube 4-6-12/Zoodad mod/Recon smoked cab lights/MM Hubs/Cowl Hood/HPx
|
|
#15
Wed, October 12th, 2011, 12:07 PM
|
|||
|
|||
|
Also, sometimes it's an under/over drive...it will never give you 1:1 ratio. I think for a dedicated hauler it would be a good option.
__________________
01 F350 7.3 4x4 CC SRW/3.73/315-75-16/Aeroforce Interceptor/BD Thruster II/ Bellowed Up-Pipes/4" turbo back exhaust/CCV Mod/DIY 6637/FPR Shimmed to 65 PSI/TS chip reburned with PHP tunes (Stock, 40T WITH Whsiper tune, 80DD, 100R, 140Ex, 140SS)/Replaced and Cleaned EBPS & Tube 4-6-12/Zoodad mod/Recon smoked cab lights/MM Hubs/Cowl Hood/HPx
|
|
#16
Wed, October 12th, 2011, 05:05 PM
|
|||
|
|||
|
US Gear got bought out & no longer makes or services the O/U units, I just found this out last week from Barney. He has one & loves it. From what I seen when I was looking into it a few years ago I didn't think the Gear Vender was even close to the US Gear in strength, but then again I don't know everything...lol
__________________
2000 F-250 SCLB 2wd 7.3 auto PHP stock-65t-80dd-120race-high idle-no start 4"tb exh, wicked wheel, 3 guages, AIS, coolant filt,
|
|
#17
Thu, October 13th, 2011, 10:25 AM
|
||||
|
||||
|
Cool, thanks
|
|
#18
Thu, October 13th, 2011, 02:56 PM
|
|||
|
|||
|
Quote:
__________________
01 F350 7.3 4x4 CC SRW/3.73/315-75-16/Aeroforce Interceptor/BD Thruster II/ Bellowed Up-Pipes/4" turbo back exhaust/CCV Mod/DIY 6637/FPR Shimmed to 65 PSI/TS chip reburned with PHP tunes (Stock, 40T WITH Whsiper tune, 80DD, 100R, 140Ex, 140SS)/Replaced and Cleaned EBPS & Tube 4-6-12/Zoodad mod/Recon smoked cab lights/MM Hubs/Cowl Hood/HPx
|
|
|
|
Linear Mode
