![]() |
|
1999 to 2003 7.3L Power Stroke Diesel 7.3L Power Stroke Diesel equipped Super Duty and Excursion. |
![]() |
|
Thread Tools
![]() |
Display Modes
![]() |
#11
|
|||
|
|||
![]()
here is a pic of the pushed up square O ring, just a note the only part of the O ring that is pushed up is were the opening is oh the steel ring that holds it down.
How can I make the pics bigger??
__________________
Jay 413-222-8286 I got hay for sale '97 F350 CC, DRW, pickup, 7.3, E4OD, 2wd, 4.10, 405K '00 F550 reg cab, 11' flatbed, 4x4, 7.3, 6637, 4R100 (soon to be a ZF6), 290k '97 GMC 5500, getting a transplant, 3.36, sleeper, 350k Abolish the Federal Reserve, They are the #1 problem. www.prisonplanet.com |
#12
|
||||
|
||||
![]()
Subscribing.
__________________
Dan 1999 F550 4x4 ZF6 pulling a Cedar Creek 36RLTS. 1999 VW Jetta TDI 5speed stick, all stock. 1996 Audi A4 Quattro. Unstoppable in the snow and ice. The single most important thing in life is the condition of the human soul. All deeds, whether they are good or evil, spring up from that. |
#13
|
|||
|
|||
![]()
so i put in the single shot injectors got the truck started after a few tries and it idle nice for about 10 minuets, then cut out
![]() ![]() I checked all fuses, the fuel heater curcit has power. Mabye I have some crap in the IPR vavle? I am going to pull it and check it out. If some one has a sugestion you can call me I will be out in the barn working on it. 413-222-8286
__________________
Jay 413-222-8286 I got hay for sale '97 F350 CC, DRW, pickup, 7.3, E4OD, 2wd, 4.10, 405K '00 F550 reg cab, 11' flatbed, 4x4, 7.3, 6637, 4R100 (soon to be a ZF6), 290k '97 GMC 5500, getting a transplant, 3.36, sleeper, 350k Abolish the Federal Reserve, They are the #1 problem. www.prisonplanet.com |
#14
|
|||
|
|||
go'er Running
It turns out the HPOP crapped out
![]() When comparing the bad pump and the pump I decided to use as a replacement I notice the bad pump had some end play ![]() The weird thing was after I put it all back together, it would not start and only push about 150 psi on the HPOP gauge ![]() ![]() ![]() I wonder if the IPR was jammed up and the 12volt was able to free it up. I took the truck for a drive around the throttle is very snappy, and it sounds just like my ’95 ![]() ![]() ![]() It did idle like a big cammed gasser once it warmed up, and also idles at 900-950 rpm at a stop in drive I will post my finding after I get home from NY with my load of hay tomorrow. Thanks again Dave and Bill for the help.
__________________
Jay 413-222-8286 I got hay for sale '97 F350 CC, DRW, pickup, 7.3, E4OD, 2wd, 4.10, 405K '00 F550 reg cab, 11' flatbed, 4x4, 7.3, 6637, 4R100 (soon to be a ZF6), 290k '97 GMC 5500, getting a transplant, 3.36, sleeper, 350k Abolish the Federal Reserve, They are the #1 problem. www.prisonplanet.com |
#15
|
|||
|
|||
![]()
I ran this truck almost 800 miles since the last post, and I like what I have experienced
![]() I was getting less that 7mpg ![]() ![]() On the way to NY there is a 6 mile hill on I90 westbound that is about a 7% grade (I could be wrong). This truck has always had to run in 3rd gear like 50 mph with my foot to the floor to pull this hill, yesterday I was able to pull it 65-68 mph with about 2/3 throttle and I was able to stay in 4th gear (OD) the whole way there ![]() The boost was low with the red waste gate actuator hose hooked up, I could only get 11 psi and the EGT would only get to 1200*, So I unhooked the red hose and was able to do max boost of 19-21 psi and the EGT would only get to 1050*. I don’t think I am getting any turbo surge. On the way home I was able to pull the load 60-65mph (that’s the fastest I will run loaded) with ease, before 50-55mph was a struggle. There is 4 or 5 hills I would normally be in 2nd gear by the top, I was able to hold 4th most of the time and only down shifted to 3rd, no 2nd gear on any hills. I didn’t fill up yet but judging by the fuel gauge level, I think I got 10mpg ![]() A few things to keep in mind, it was a picture perfect 2 days in the north east high in the 70’s and no wind. Keep in mind wind is a big factor, all winter long there is a good west to east wind, so on my way out to NY I am fighting a head wind ![]() As for the HPOP pressure, it will max out at 2800psi, but not until I get it to 2650rpm. It will hold 2500-2600psi @ full throttle from 1800rpm and up. I you are scratching your head I will fill in the blanks, maybe. ’00 F550, 7.3, 290k, 4R100, billet low stall converter, 4.88, 4” turbo back, 8R19.5 Cooper C140, 6637 intake, SP TCC lock, 90cc single shots. No tuning but I need/want it. Now for the issues, Rough idle sound like a lame cammed up gasser. Has a very high idle (950rpm) in gear, but smooth. You need to stand on the brake at a stop with the low stall TC. When cruising with a light throttle, it is a bit herky-jerky, the power is on and then off. This is what Bill should be able to straighten out.
__________________
Jay 413-222-8286 I got hay for sale '97 F350 CC, DRW, pickup, 7.3, E4OD, 2wd, 4.10, 405K '00 F550 reg cab, 11' flatbed, 4x4, 7.3, 6637, 4R100 (soon to be a ZF6), 290k '97 GMC 5500, getting a transplant, 3.36, sleeper, 350k Abolish the Federal Reserve, They are the #1 problem. www.prisonplanet.com |
#16
|
||||
|
||||
![]()
Awesome!
Glad to hear it's up and working for you. |
#17
|
|||
|
|||
![]()
what should a 17* HPOP max out at (pressure), I am also thinking I may need more then 90cc of fuel.
__________________
Jay 413-222-8286 I got hay for sale '97 F350 CC, DRW, pickup, 7.3, E4OD, 2wd, 4.10, 405K '00 F550 reg cab, 11' flatbed, 4x4, 7.3, 6637, 4R100 (soon to be a ZF6), 290k '97 GMC 5500, getting a transplant, 3.36, sleeper, 350k Abolish the Federal Reserve, They are the #1 problem. www.prisonplanet.com |
#18
|
||||
|
||||
![]()
All depends on tuning, and injector type/ size.
But with stock programming all you are going to see is 2800psi. |
#19
|
|||
|
|||
![]()
thats what it's doing.
If I was to crank it up with tuning, high high can it safely go? Will bumping the HPOP pressure do much for power or economy? I want to do all I can to squezz out all mpg i can.
__________________
Jay 413-222-8286 I got hay for sale '97 F350 CC, DRW, pickup, 7.3, E4OD, 2wd, 4.10, 405K '00 F550 reg cab, 11' flatbed, 4x4, 7.3, 6637, 4R100 (soon to be a ZF6), 290k '97 GMC 5500, getting a transplant, 3.36, sleeper, 350k Abolish the Federal Reserve, They are the #1 problem. www.prisonplanet.com |
#20
|
||||
|
||||
![]() Quote:
Do you have a chip on order? |
![]() |
|
|